DR DUAL-ACTION ELECTRIC Betriebsanleitung

Read and understand this manual and all instructions before operating the DR Dual-Action Electric Log Splitter. `Original Language DR® DUAL-ACTION EL

10 DR® DUAL-ACTION ELECTRIC LOG SPLITTER 6. Install the Castle Nut onto the Axle Threads with a 1-1/2" Wrench until the Tapered Bearing

CONTACT US AT www.DRpower.com 11 Figure 16 Control Lever Jam Nut Flat Washer Note: Remove protective Caps as needed for the following Hydrau

12 DR® DUAL-ACTION ELECTRIC LOG SPLITTER 29. Install the Trays onto the sides of the Beam assembly by aligning the legs with the receiving tub

CONTACT US AT www.DRpower.com 13 Check the Tire Pressure Tools Needed:  Tire Pressure Gauge  Air Compressor 5. Remove the Valve Stem Pro

14 DR® DUAL-ACTION ELECTRIC LOG SPLITTER Chapter 3: Operating Your DR DUAL-ACTION ELECTRIC LOG SPLITTER It may be helpful to better familiariz

CONTACT US AT www.DRpower.com 15 Hands on Sides of Wood Figure 26 Wood Against Stop Base Splitting Note: All logs should be no longer than 2

16 DR® DUAL-ACTION ELECTRIC LOG SPLITTER 3. Hold the Valve Control Handle, moving the Wedge towards the Log until the log is split or the cy

CONTACT US AT www.DRpower.com 17

18 DR® DUAL-ACTION ELECTRIC LOG SPLITTER Chapter 4: Maintaining The DR DUAL-ACTION ELECTRIC LOG SPLITTER Regular maintenance is the way to ens

CONTACT US AT www.DRpower.com 19 Hydraulic Fluid Change Tools and Supplies Needed:  Adjustable Wrench  Clean Rags  Approved Container (

2 DR® DUAL-ACTION ELECTRIC LOG SPLITTER This indicates a hazardous situation, which, if not avoided, could result in death or serious injury.

20 DR® DUAL-ACTION ELECTRIC LOG SPLITTER Replacing the Wheels Tools and Supplies needed:  Channel lock Pliers  Clean Rags  Adjustable Wr

CONTACT US AT www.DRpower.com 21 Adjusting the Pressure Valve The Log Splitter is set at the factory to optimize splitting force. The follow

22 DR® DUAL-ACTION ELECTRIC LOG SPLITTER

CONTACT US AT www.DRpower.com 23 Chapter 5: Troubleshooting Most problems are easy to fix. Consult the Troubleshooting Table below for common

24 DR® DUAL-ACTION ELECTRIC LOG SPLITTER Troubleshooting Table (Continued) SYMPTOM POSSIBLE CAUSE Ram advances with a jerky motion or with str

CONTACT US AT www.DRpower.com 25 Chapter 6: DR DUAL-ACTION ELECTRIC LOG SPLITTER Road Towable Kit Tools and Supplies Needed:  Two 7/16"

26 DR® DUAL-ACTION ELECTRIC LOG SPLITTER 18. Assemble the Fenders to the Frame with eight 5/16-18 x 3/4" Carriage Bolts (fender side) and

CONTACT US AT www.DRpower.com 27 Figure 45 Lock Nut Ball Clamp Spring Figure 44 Pull Locking Trigger 1/16" Movement Attaching to Tow Veh

28 DR® DUAL-ACTION ELECTRIC LOG SPLITTER Chapter 7: Parts Lists, Schematic Diagrams And Warranty Parts List - FRAME ASSEMBLY NOTE: Part number

CONTACT US AT www.DRpower.com 29 Schematic – FRAME ASSEMBLY

CONTACT US AT www.DRpower.com 3 Read this safety & operating Instructions manual before you use the DR DUAL-ACTION ELECTRIC LOG SPLITTER

30 DR® DUAL-ACTION ELECTRIC LOG SPLITTER Parts List – BEAM ASSEMBLY NOTE: Part numbers listed are available through DR Power Equipment. Ref#

CONTACT US AT www.DRpower.com 31 Schematic – BEAM ASSEMBLY

32 DR® DUAL-ACTION ELECTRIC LOG SPLITTER Parts List – MOTOR AND PUMP ASSEMBLY NOTE: Part numbers listed are available through DR Power Equipme

CONTACT US AT www.DRpower.com 33 Schematic – MOTOR AND PUMP ASSEMBLY

34 DR® DUAL-ACTION ELECTRIC LOG SPLITTER Parts List – ROAD-TOW ACCESSORY NOTE: Part numbers listed are available through DR Power Equipment.

CONTACT US AT www.DRpower.com 35 Schematic – ROAD TOW ACCESSORY

75 MEIGS ROAD, P.O. BOX 25, VERGENNES, VERMONT 05491 ©2013 Country Home Products, Inc. All rights reserved 276151A Daily Checklist for the DR DUAL-A

4 DR® DUAL-ACTION ELECTRIC LOG SPLITTER High fluid pressures are developed in hydraulic machines. Pressurized hydraulic fluid escaping throug

CONTACT US AT www.DRpower.com 5 Never overlook the hazards of electricity. Always follow these precautions:  Never open the switch box or

6 DR® DUAL-ACTION ELECTRIC LOG SPLITTER A Note to All Users No list of warnings and cautions can be all-inclusive. If situations occur that

CONTACT US AT www.DRpower.com 7 Figure 1 Jack Pneumatic Tires Operator Lever Chapter 2: Setting Up The DR DUAL-ACTION ELECTRIC LOG SPLITTER

8 DR® DUAL-ACTION ELECTRIC LOG SPLITTER Specifications Motor 1.8kW, 110V AC Motor Bed height 24" (610mm) Wedge 6.61" (168mm) h, .7

CONTACT US AT www.DRpower.com 9 1. Open the Parts Box and lay them out on a clean flat area (Figure 2). Note: For assembly location, the pa