DR® FIELD and BRUSH MOWER SAFETY & OPERATING INSTRUCTIONS Serial No. Order No. DR Power Equipment Toll-free phone: 1-800-DR-OWNER (376-9637) Fax
10 DR® FIELD and BRUSH MOWER Connecting the Battery Wire We ship all Electric-Starting Mowers with the negative terminal Battery wire disconn
CONTACT US AT www.DRpower.com 11 Chapter 3: Operating The DR FIELD and BRUSH MOWER This chapter covers the procedures for starting and stopp
12 DR® FIELD and BRUSH MOWER Before Starting the Engine 1. Check the oil level every time you use the machine. 2. Check the gas level. 3.
CONTACT US AT www.DRpower.com 13 5. Turn the Key to the OFF position and remove it for safety. NOTE: If your machine is equipped with a Fue
14 DR® FIELD and BRUSH MOWER Cutting Brush and Saplings 1. When cutting woody material, small saplings, etc., allow the machine to ride up a
CONTACT US AT www.DRpower.com 15 Before performing any maintenance procedure or inspection, stop the engine, wait five (5) minutes to allow a
16 DR® FIELD and BRUSH MOWER 1. Slide one end of the Clear Plastic Tube over the Oil Drain Connector (Figure 10 Kawasaki, Figure 11 Briggs)
CONTACT US AT www.DRpower.com 17 1. There is one Grease Fitting below the black Belt Guard that needs lubrication (Figure 13): • The Belt I
18 DR® FIELD and BRUSH MOWER Figure 20 3 Belt Guides Clutch Drive Spring Removed Clutch Bracket 3. Remove the Belt from the Pulley (Fig
CONTACT US AT www.DRpower.com 19 9. Loosen the Belt Retainer Bolts on the outside of the Frame (one on each side) and slide the Retainer bac
2 DR® FIELD and BRUSH MOWER Table of Contents Chapter 1: General Safety Rules ...
20 DR® FIELD and BRUSH MOWER Before performing any maintenance procedure or inspection, stop the engine, wait five (5) minutes to allow all p
CONTACT US AT www.DRpower.com 21 Adjusting the Differential Lock In/Out Cable NOTE: If the Differential will not Lock In or Out, the Cable m
22 DR® FIELD and BRUSH MOWER Adjusting the Parking Brake Tools needed: • 1/2" Open End Wrench 1. Tighten or loosen the Parking Brake A
CONTACT US AT www.DRpower.com 23 Replacing the Push Tube Skid Tools and Supplies Needed: • Two 1/2" Wrenches • Blocks 1. Lift the Pus
24 DR® FIELD and BRUSH MOWER 3. Remove the Bolts from the Right side of the Fuel Tank Mount with a 7/16" Wrench (Figure 39). 4. Reposi
CONTACT US AT www.DRpower.com 25 Please dispose of used batteries responsibly, according to your local hazardous materials regulations. Neve
26 DR® FIELD and BRUSH MOWER Chapter 5: Troubleshooting Most problems are easy to fix. Consult the Troubleshooting Table below for common pro
CONTACT US AT www.DRpower.com 27 Troubleshooting Table (Cont.) SYMPTOM POSSIBLE CAUSE Engine runs fine but the machine will not move. ⇒ The
28 DR® FIELD and BRUSH MOWER Troubleshooting Table (Cont.) SYMPTOM POSSIBLE CAUSE Wheels pulling left or right. ⇒ Check the Wheel Tire pre
CONTACT US AT www.DRpower.com 29
CONTACT US AT www.DRpower.com 3 Chapter 1: General Safety Rules Labels Your DR FIELD and BRUSH MOWER carries prominent labels as reminders fo
30 DR® FIELD and BRUSH MOWER Chapter 6: Parts Lists, Schematic Diagrams And Warranty Parts List - Handlebar Assembly NOTE: Part numbers liste
CONTACT US AT www.DRpower.com 31 Schematic – Handlebar Assembly 101210
32 DR® FIELD and BRUSH MOWER Parts List – Power Assembly NOTE: Part numbers listed are available through DR Power Equipment. Ref# Part# Des
CONTACT US AT www.DRpower.com 33 Schematic – Power Assembly 040211
34 DR® FIELD and BRUSH MOWER Parts List – Brush Deck Assembly NOTE: Part numbers listed are available through DR Power Equipment. Ref# Part#
CONTACT US AT www.DRpower.com 35 Schematic – Brush Deck Assembly 121710
36 DR® FIELD and BRUSH MOWER Parts List – Frame and Drive Assembly NOTE: Part numbers listed are available through DR Power Equipment. Ref#
CONTACT US AT www.DRpower.com 37 Schematic – Frame and Drive Assembly 040211
38 DR® FIELD and BRUSH MOWER Wiring Diagram – Briggs and Stratton Electric Start040311
CONTACT US AT www.DRpower.com 39 Wiring Diagram – Kawasaki Electric Start 031810
4 DR® FIELD and BRUSH MOWER Tragic accidents can occur if the operator is not alert to the presence of children and pets. Children are often
40 DR® FIELD and BRUSH MOWER Notes:
CONTACT US AT www.DRpower.com 41 Notes:
42 DR® FIELD and BRUSH MOWER Warranty CALIFORNIA EVAPORATIVE EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The C
CONTACT US AT www.DRpower.com 43 (2) Any warranted part that is scheduled only for regular inspection in the written instructions supplied is
75 MEIGS ROAD, P.O. BOX 25, VERGENNES, VERMONT 05491 ©2011 Country Home Products, Inc. All rights reserved 283421A Daily Checklist for the DR FIELD
CONTACT US AT www.DRpower.com 5 Slope Operation General SafetySlopes are a major factor related to slip and fall accidents, which can result
6 DR® FIELD and BRUSH MOWER A Note to All Users Under California law, and the laws of some other states, you are not permitted to operate an
CONTACT US AT www.DRpower.com 7 Figure 1 Chapter 2: Setting Up The DR FIELD and BRUSH MOWER It may be helpful to familiarize yourself with t
8 DR® FIELD and BRUSH MOWER Specifications Premier Pro Pro-XL Engine See Engine Owners Manual for details See Engine Owners Manual for de
CONTACT US AT www.DRpower.com 9 6. Attach the Deck to the Power Unit following the directions in the next section. The Belt is stored below
Kommentare zu diesen Handbüchern